微酸多年卧孔菌产漆酶条件优化及其在染料脱色中的应用

微酸多年卧孔菌(Perenniporia subacida)产漆酶能力对生物漂白等研究具有重要意义.通过单因子和正交试验确定了微酸多年卧孔菌(菌株号:Dai 8224)的最适产酶条件:麦芽糖20 g/L,酵母浸粉5 g/L,pH 5.4,Cu2+2.0 mmol/L,培养温度24℃,转速160 r/min,接种量1.5%(V/V),此时酶活最高可达1.945 U/mL.单独使用微酸多年卧孔菌漆酶粗酶液对染料具有很好的脱色效果.该菌株对于50 mg/L杂环类染料中性红的脱色率可达98.3%,对偶氮染料刚果红的脱色率次之,为91.57%,对亚甲基蓝和铬天青的脱色率也都在80%以上.此外,其催化中性红脱色的最佳底物浓度为60 mg/L,脱色率达到99.42%,其中,生物降解作用占55.92%,菌体吸附作用占43.5%.结果表明该菌对多种染料脱色具有较大的应用潜力.图4表3参31     

餐厨垃圾固态发酵过程中挥发性脂肪酸与产气的变化关系研究

为了研究餐厨垃圾固态发酵过程中挥发性脂肪酸(VFAs)与产气的变化关系,采用中温(37.0±0.2)℃连续式发酵,在完全混合CSTR反应器中连续运行100 d,分析餐厨垃圾固态发酵过程的启动、运行、失衡、失衡后恢复及实现固态发酵全过程各参数的变化趋势,重点研究VFAs各成分与产气、pH等的关系.结果表明,餐厨垃圾固态发酵实验过程可划分为4个时期:适应期(0~13 d)、启动期(14~30 d)、抑制期(31~50d)、恢复及稳定期(51~100 d).不同时期的容积产气率、VFAs及各参数均表现出不同的阶段性变化.在餐厨垃圾固态发酵全过程中,pH保持在5~7之间,正丁酸比例一直处于较高水平;VFAs与pH和容积产气率在初期基本保持反比关系,最终在稳定期达到平衡,均稳定在一定范围内波动.在恢复及稳定阶段以NaOH稀碱液调节当日回流渗滤液的pH值,在第63 d时pH值上升至6.76,VFAs含量稳定在20~22 g·L~(-1)之间,产气量明显提高;在81 d时TS达到20%以上,系统容积产气量和生物降解率均保持相对稳定.     

水稻与棉花秸秆不同预处理厌氧发酵产沼气

以猪粪为接种物,以棉花秸秆和水稻秸秆为发酵原料,分别对秸秆进行稀碱法预处理和稀碱法与超声波联合预处理,在发酵温度为(37±1)℃的条件下进行厌氧发酵产沼气的研究。结果表明,以联合预处理的秸秆为发酵原料,厌氧发酵的各项指标均比以稀碱预处理秸秆发酵的效果好,其中累积产气量和沼气中甲烷含量分别提高35.23%和2.4%,发酵后TS、VS含量相对减少2.6%～10.94%,发酵液代谢产物中的有机酸丙酮酸、乙酸和柠檬酸含量相对减少23.9%～25.9%、20.24%～24.53%和41.08%～45.91%。     

Penicillin fermentation residue biochar as a high-performance electrode for membrane capacitive deionization

● We have provided an activated method to remove the toxicity of antibiotic residue. ● PFRB can greatly improve the salt adsorption capacity of MCDI. ● The hierarchical porous and abundant O/N-doped played the key role for the high-capacity desalination. ● A new field of reuse of penicillin fermentation residue has been developed. Membrane capacitive deionization (MCDI) is an efficient desalination technology for brine. Penicillin fermentation residue biochar (PFRB) possesses a hierarchical porous and O/N-doped structure which could serve as a high-capacity desalination electrode in the MCDI system. Under optimal conditions (electrode weight, voltage, and concentration) and a carbonization temperature of 700 °C, the maximum salt adsorption capacity of the electrode can reach 26.4 mg/g, which is higher than that of most carbon electrodes. Furthermore, the electrochemical properties of the PFRB electrode were characterized through cyclic voltammetry (CV) and electrochemical impedance spectroscopy (EIS) with a maximum specific capacitance of 212.18 F/g. Finally, biotoxicity tests have showed that PFRB was non-biotoxin against luminescent bacteria and the MCDI system with the PFRB electrode remained stable even after 27 adsorption–desorption cycles. This study provides a novel way to recycle penicillin residue and an electrode that can achieve excellent desalination.     

水生植物酸碱预处理对厌氧发酵联产氢气-甲烷的影响简

采用酸碱预处理乌梁素海典型沉水植物龙须眼子菜和挺水植物芦苇，通过厌氧发酵动力学分析、还原糖变化及微观结构解析，研究酸碱预处理对水生植物厌氧发酵联产氢气-甲烷的影响。实验结果表明，酸碱预处理后水生植物厌氧发酵联产氢气-甲烷两阶段累积产气量、氢气及甲烷含量均显著提高，酸处理效果优于碱处理。采用0.5 mol/L HCl预处理龙须眼子菜效果最佳，最大氢气、甲烷含量分别达42.65%和52.82%，产氢气速率为4.118 mL/h，产甲烷速率最高达14.199 mL/h。芦苇经1 mol/L HCl预处理效果最佳，最高氢气、甲烷含量分别为32.22%和65.26%。扫描电镜微观结构分析表明，酸碱预处理可显著破坏芦苇、龙须眼子菜的纤维素结构，有效增加植物与微生物接触面积，有利于厌氧发酵联产氢气-甲烷工艺的快速启动和稳定运行。     

Low-temperature caproate production,microbial diversity,and metabolic pathway in xylose anaerobic fermentation

● Converting xylose to caproate under a low temperature of 20 °C by MCF was verified. ● Final concentration of caproate from xylose in a batch reactor reached 1.6 g/L. ● Changing the substrate to ethanol did not notably increase the caproate production. ● Four genera, including Bifidobacterium , were revealed as caproate producers. ● The FAB pathway and incomplete RBO pathway were revealed via metagenomic analysis. Mixed culture fermentation (MCF) is challenged by the unqualified activity of enriched bacteria and unwanted methane dissolution under low temperatures. In this work, caproate production from xylose was investigated by MCF at a low temperature (20 °C). The results showed that a 9 d long hydraulic retention time (HRT) in a continuously stirred tank reactor was necessary for caproate production (~0.3 g/L, equal to 0.6 g COD/L) from xylose (10 g/L). The caproate concentration in the batch mode was further increased to 1.6 g/L. However, changing the substrate to ethanol did not promote caproate production, resulting in ~1.0 g/L after 45 d of operation. Four genera, Bifidobacterium, Caproiciproducens, Actinomyces, and Clostridium_sensu_stricto_12, were identified as the enriched caproate-producing bacteria. The enzymes in the fatty acid biosynthesis (FAB) pathway for caproate production were identified via metagenomic analysis. The enzymes for the conversion of (C_n+2)-2,3-Dehydroxyacyl-CoA to (C_n+2)-Acyl-CoA (i.e., EC 1.3.1.8 and EC 1.3.1.38) in the reverse β-oxidation (RBO) pathway were not identified. These results could extend the understanding of low-temperature caproate production.     

炭纤维载体固定床厌氧发酵启动运行效果实验

以开发高效率、抗冲击性能强的高浓度有机废水沼气发酵技术为目的，用传统的 UASB反应器作为对照，研究了以炭纤维为生物膜载体的固定床厌氧反应器的启动运行效果。反应器进口废水 COD 为 5 000 mg/L, 水力停留时间 (HRT) 由213 h 逐步缩短为35 h，进水有机容积负荷(OLR)由0.56 kg COD/ (m³·d)提到3.45 kg COD/(m³·d)。结果表明，固定床反应器厌氧发酵的效率比对照高，出水 pH 值也比对照稳定；运行到第 50 d 时，固定床厌氧反应器和对照的 COD去除率分别由第 7 d 的36.56%和33.58%上升到87.9%和62.6%；固定床厌氧反应器的容积比产气率最高为1.16 m³/(m³·d)，累计产气量为415.59 L，而对照的容积比产气率最高值仅为0.31 m³ /(m³·d)，累计产气量为 71.66 L，前者最高容积比产气率和累计产气量分别是后者的3.74倍和5.78倍。固定床厌氧反应器的启动速度、COD 去除率和产甲烷效率显著地高于对照反应器。     

Kinetics study of fermentative hydrogen production from liquid swine manure supplemented with glucose under controlled pH

Kinetics of H₂ production from liquid swine manure supplemented with glucose by mixed anaerobic cultures was investigated using batch experiments under four different pH conditions (4.4, 5.0, 5.6, and uncontrolled). The temperature for the experiments was controlled at 37 ± 1°C and the length of experiments varied between 50 and 120 hours, depending upon the time needed for completion of each individual experiment. The modified Gompertz model was evaluated for its suitability for describing the H₂ production potential, H₂ production rate, and substrate consumption rate for all the experiments. The results showed that the Gompertz model could adequately fit the experimental results. The effect of pH was significant on all kinetic parameters for H₂ production including yield, production rate and lag time, and the substrate utilization rate. The optimal pH was found to be 5.0, at which a maximum H₂ production rate (0.64 L H₂/h) was obtained, and deviation from the optimal pH could result in substantial reductions in H₂ production rate (0.32 L H₂/h for pH 4.0 and 0.43 L H₂/h for pH 5.6). The results also showed that if pH was not controlled for the batch fermentation process, the substrate utilization efficiency could steeply decrease from 98.8% to 33.7%.     

响应面法和神经网络优化Acinetobactersp．DNS32发酵基质

为了提高阿特拉津降解菌Acinetobactersp．DNS32的产量，分别采用响应曲面法和基于人工神经网络的遗传算法对阿特拉津降解菌DNS32发酵培养基中3个重要基质成分（玉米粉、豆饼粉、K：HPO。）进行优化研究。响应曲面法确定3种成分的含量为玉米粉39．494g／L，豆饼粉25．638g／L和K。HPO。3．265g／L时，预测发酵活菌最大生物量为7．079×10^8CFU／mL，实测量为7．194×10^8CFU／mL；人工神经网络结合遗传算法优化确定3种主要成分含量为玉米粉为39．650g／L，豆饼粉为25．500g／L，K2HPO4为2．624g／L时，预测最大值为7．199×10^8CFU／mL，实测量为7．244×10。CFU／mL；最终确定培养基配方：玉米粉为39．650g／L，豆饼粉为25．500g／L，K2HPO4为2．624g／L，CaCO3为3．000g／L，MgSO4·7H2O和NaCl均为0．200g／L；优化后阿特拉津降解菌DNS32发酵生物量比优化前提高了36．6％。结果表明，在阿特拉津降解菌DNS32发酵培养基组分优化方面，响应面法和基于人工神经网络的遗传算法都是可行的，基于人工神经网络的遗传算法具有更好的拟合度和预测准确度。     

腐熟蓝藻与厌氧污泥混合厌氧发酵特性

采用批次小试实验对不同腐熟程度的蓝藻进行厌氧发酵产沼气实验研究。结果表明,新鲜蓝藻在30-35℃时腐熟7 d后,可在35℃的厌氧温度下获得最高的产气速率和246 mL/g COD的产气量,产气潜力为354 mL/g（VS）。厌氧反应15 d后,累计产气量、COD和VFA浓度趋于稳定。淀粉酶和脱氢酶的活性在厌氧反应初期受到抑制,蛋白酶活性和辅酶F420浓度在厌氧系统中逐渐增加,分别在第6天达到27.66μmol/（g VS·min）和第15天达到0.62μmol/g（VS）。15-18d是腐熟蓝藻适宜的中温厌氧发酵时间,少于以新鲜蓝藻为基质的厌氧消化时间。蓝藻腐熟过程促进了厌氧反应,腐熟7 d的蓝藻厌氧系统具有更高的微生物活性和产甲烷能力。